Since the working environment of the charging mixer is relatively bad, plus the user does not pay attention to the daily maintenance, it has caused some unnecessary failures and economic losses. I hope that through the introduction of the charging mixer from Zhongke, the following introduction will play a role in the daily use and maintenance of the majority of users of the charging mixer.

一、應該保養自上料攪拌機罐體,每次運完混凝土后及進清洗罐,要知道混凝土是更容易和鋼鐵粘結在一起的。

1、 First of all, the tank body of the charging mixer should be maintained. Every time the concrete is transported and into the cleaning tank, it is necessary to know that the concrete is easy to bond with steel.
                 

二、出料的勻稱性問題是自上料攪拌機的一個重要指標之一,它直接影響著施工質量。在運送混凝土時,攪拌筒轉速應節制在2~5r/min,在運送間隔較長可能混凝土的塌落度較大時,出料前應先將攪拌筒快速動彈5~10圈,使內里的混凝土能充實攪拌,這樣出料的勻稱性就會大大提高。若途中混凝失水,到工地應加水調解,并充實攪拌,雖然這種環境應只管制止,但是這樣會使混凝土的質量得不到擔保。有的用戶在利用時不留意節制在運輸歷程中的轉速,過快會增大燃油的耗損,過小則會造成混凝土離析。因此應嚴格憑據要求來節制攪拌筒的轉速,以提高混凝土運送質量。

2、 The uniformity of discharge is one of the important indexes of self loading mixer, which directly affects the construction quality. When transporting concrete, the rotation speed of mixing drum should be controlled at 2 ~ 5R / min. if the transportation interval is long and the slump of concrete is large, the mixing drum should be moved 5 ~ 10 times before discharging, so that the concrete inside can be fully mixed, so that the uniformity of discharge will be greatly improved. If the concrete loses water on the way, water should be added to the construction site for mediation and full mixing. Although this kind of environment should only be stopped, the quality of concrete will not be guaranteed. Some users do not pay attention to control the speed in the transportation process, too fast will increase the fuel consumption, too small will cause concrete segregation. Therefore, the rotation speed of mixing drum should be controlled strictly according to the requirements, so as to improve the quality of concrete transportation.

三、凝土限量不能高出罐體的方量,因為混凝土強度品級差別它的密度也差別,高強度混凝土一般密度也大,同樣的體積,裝多了對車倒霉。輸送混凝土的容量、質量及坍落度應切合車輛利用說明書中的規定,實時加注潤滑油。

3、 The maximum limit of concrete can not be higher than the maximum volume of the tank, because the concrete strength grade is different, its density is also different, high strength concrete is generally of high density, the same volume, too much loading is bad for cars. The capacity, quality and slump of concrete to be transported shall be in accordance with the provisions in the vehicle operation manual, and lubricating oil shall be added in real time.

四、露天停放過的自上料攪拌機,裝料前應先將攪拌筒以出料偏向旋轉,把水泥罐內的積水放掉,確保運送混凝土的質量。

4、 For the self loading mixer that has been parked in the open air, the mixing drum should be rotated in the direction of discharging before loading, and the water in the cement tank should be drained to ensure the quality of concrete transported.

以上是關于日常維護自上料攪拌機的相關內容，希望對你們有所幫助，想要了解更多內容歡迎點擊中科自上料攪拌機www.jbckj.cn官網。

The above is about the daily maintenance of self feeding mixer related content, hope to help you, if you want to learn more, welcome to click Zhongke self feeding mixer www.jbckj.cn Official website.