混凝土自上料攪拌車干燥罐定期更新是必然的
混凝土自上料攪拌車干燥罐用來過濾氣路系統內壓縮空氣中水蒸氣的，防止儲氣筒和各類泵閥遭到腐蝕，因此，混凝土自上料攪拌車燥罐能否正常工作，直接影響到性能。其中混凝土自上料攪拌車干燥罐定期更新是必然的，下面來簡單講講吧。
The drying tank of the concrete self loading mixer truck is used to filter the water vapor in the compressed air in the air circuit system and prevent the air reservoir and various pump valves from being corroded. Therefore, whether the drying tank of the concrete self loading mixer truck can work normally directly affects the performance. Among them, it is inevitable to update the drying tank of concrete self loading mixer truck regularly. Let's talk about it briefly below.
混凝土自上料攪拌車干燥罐雖然不貴，但是很多用戶還是能省就省，對干燥罐的品質也無所謂，只要有一個能用就行，有的甚幾年都不換一次。更換干燥罐的操作并不繁瑣，利用氣罐底部的放氣閥門，來查看氣罐底部是否潮濕，或者有水。如果干燥罐失效，打開閥門之后會有水流出，應該立即更換新的干燥罐。
Although the drying tank of concrete self loading mixer truck is not expensive, many users can still save, and it doesn't matter about the quality of the drying tank. As long as one can be used, some don't even change it once a few years. The operation of replacing the drying tank is not cumbersome. Use the vent valve at the bottom of the air tank to check whether the bottom of the air tank is wet or there is water. If the drying tank fails, water will flow out after opening the valve, and a new drying tank should be replaced immediately.
好多人都是只要不出問題，幾年可能都不會換一次。并且不同企業的干燥罐使用壽命不一樣，而且車輛行駛的氣候環境也有差異，更換的周期就很難統一。如果混凝土自上料攪拌車司機們實在不知道何時該更換，可以通過查看儲氣筒是否有積水的方法來判斷。
Many people may not change once in a few years as long as there is no problem. Moreover, the service life of drying cans of different brands is different, and the climatic environment of vehicles is also different, so it is difficult to unify the replacement cycle. If the mixer truck drivers don't know when to replace the concrete, they can judge by checking whether there is water in the air reservoir.
但是在這里也要提醒司機朋友們，因?yàn)榛炷磷陨狭蠑嚢柢嚫稍锕捱B接著氣路，罐體內部與外界有一定的壓力差，壓縮空氣未排空時冒然拆卸，壓縮空氣瞬間釋放，易對拆卸人員造成傷害。
However, it is also necessary to remind the drivers here that since the drying tank of the concrete loading mixer truck is connected with the air circuit, there is a certain pressure difference between the inside of the tank and the outside world. When the compressed air is not emptied, it is disassembled rashly, and the compressed air is released instantly, which is easy to cause harm to the disassemblers.
所以要排空儲氣筒內空氣（反復踩踏剎車，直氣壓表讀數歸零），才可以對干燥罐進行拆卸。借助專用的扳手將干燥罐拆卸下來之后，可以在底座上看到有星星點點的水珠，可見壓縮空氣的濕度還是很大的。
Therefore, it is necessary to empty the air in the air reservoir (repeatedly press the brake until the barometer reading returns to zero), and then the drying tank can be disassembled. After the drying tank is disassembled with the help of a special wrench, you can see scattered drops of water on the base, which shows that the humidity of the compressed air is still very high.
混凝土自上料攪拌車廠家認為如果干燥罐的過濾效果差的話，這些液態水就會由氣路進入到剎車的各個泵閥。在安裝新的干燥罐之前要將底座上面清理一下，防止油污進入新罐的內部，影響性能。
The manufacturer of the concrete self loading mixer believes that if the filtering effect of the drying tank is poor, the liquid water will enter into each pump valve of the brake from the gas path. Before installing a new drying tank, clean the base to prevent oil from entering the interior of the new tank and affecting the dehumidification performance.
然后在新干燥罐下面的橡膠墊圈上要涂抹一層機油，起到潤滑的作用，防止安裝時損壞橡膠墊圈。如果使用劣質產品，或者長時間不更換導致性能喪失,將會嚴重影響整車的制動。
Then apply a layer of engine oil on the rubber washer under the new drying tank to lubricate and prevent damage to the rubber washer during installation. If inferior products are used, or the dehumidification performance is lost due to long-term non replacement, the braking of the whole vehicle will be seriously affected.
混凝土自上料攪拌車干燥罐定期更新是必然的相關內容就講解到這里了，所以說對于某些方面還是要真正的在意起來，防止出現問題影響整個工作的進度，更多內容您可以來網站www.jbckj.cn進行咨詢。
It is necessary to update the drying tank of the concrete mixer truck regularly since the loading. That's all for the relevant content. Therefore, we should really care about some aspects to prevent problems from affecting the progress of the whole work. For more content, you can consult the website.
