自上料攪拌車冬春交替時要注意保暖檢查
1。使用自上料攪拌車前，檢查水箱、閥門、管道等部件是否結冰。如果發現冰，則先除去冰，然后緩慢啟動攪拌機。
1。 Before using the self loading mixer, check whether the water tank, valve, pipeline and other parts are frozen. If ice is found, remove the ice first, and then start the mixer slowly.
2。為避免儲氣罐內的水在低溫下結冰，業主應注意及時排除罐內積水。
2。 In order to prevent the water in the air storage tank from freezing under low temperature, the owner shall pay attention to timely draining the accumulated water in the tank.
3。注意及時更換防凍液。
3。 Pay attention to timely replacement of antifreeze.
4。經常檢查和保養蓄電池的電解液和通風口。如果當?shù)販囟鹊陀?30℃，則必須將電池取出并放置在室內進行隔熱，以避免凍裂。
4。 Regularly check and maintain the electrolyte and vent of the battery. If the local temperature is lower than -30 ℃, the battery must be taken out and placed indoors for thermal insulation to avoid frost cracking.
5。攪拌機發動機啟動后，怠速運轉約3-5分鐘，然后運轉攪拌機，直達到正常潤滑、正常油壓和適當水溫。
5。 After the mixer engine is started, run it at idle speed for about 3-5 minutes, and then run the mixer until it reaches normal lubrication, normal oil pressure and appropriate water temperature.
6。攪拌機司機室空調不使用時，為方便系統正常運行，每月啟動一次，每次啟動10分鐘。
6。 When the air conditioner in the mixer cab is not in use, in order to facilitate the normal operation of the system, it shall be started once a month for 10 minutes each time.
7。當施工現場溫度低于0℃時，每天使用攪拌車后，必須將水箱和水管內的余水排干，防止水管凍裂。
7。 When the temperature at the construction site is lower than 0 ℃, the remaining water in the water tank and water pipe must be drained after using the mixer every day to prevent the water pipe from cracking.
8。冬季，北方寒冷，南方寒冷，南北溫差大。建議是根據施工現場的條件和溫度選擇符合要求的柴油，并更換相應粘度等級的油。正常情況下，當溫度高于0℃時，使用0柴油。一旦溫度低于0℃，開始使用負柴油。每10℃為一檔，每次溫度下降，柴油機車型都需要更換，分別為-10#、-20#、-30#。
8。 In winter, the north is cold, the south is cold, and the temperature difference between the north and the south is large. It is recommended to select diesel oil that meets the requirements according to the conditions and temperature of the construction site, and replace the oil with the corresponding viscosity grade. Under normal conditions, when the temperature is higher than 0 ℃, use 0 diesel oil. Once the temperature is below 0 ℃, start to use negative diesel oil. Every 10 ℃ is the first gear. Every time the temperature drops, the diesel engine models need to be replaced, which are -10\.
9。自上料攪拌車廠家建議要減少洗車次數，洗車時要用溫水，洗車后要及時擦拭水漬，否則會結冰。
9。 Since the manufacturer of the charging mixer truck suggested that the number of car washes should be reduced, warm water should be used when washing the car, and the water stains should be wiped in time after washing the car, otherwise it will freeze.
自上料攪拌車冬春交替時要注意保暖檢查的相關內容就講解到這里了，您可以關注我們的網站www.jbckj.cn，獲取到更多信息！
This is the end of the explanation about the inspection of keeping warm when the loading mixer truck alternates between winter and spring. You can follow our website www.jfjiaobanche COM, get more information!
