攪拌車的空氣濾清器什么時候該更換
攪拌車經常出入灰塵較大的攪拌站和建筑工地，它的空氣濾清器就顯得尤為重要，在這種灰塵比較多的場所，空氣濾清器就非常累，因此對它的保養要十分用心，否則就會造成發動機的非正常磨損，減少發動機的使用壽命。那么攪拌車的空氣濾清器什么時候該更換？混凝土自上料攪拌車廠家為您分析。
The air filter of the mixer truck is particularly important because it often enters and exits the mixing station and construction site with heavy dust. In such a dusty place, the air filter is very tired, so you should pay attention to its maintenance, otherwise it will cause abnormal wear of the engine and reduce the service life of the engine. When should the air filter of the mixer be replaced? The manufacturer of concrete self loading mixer will analyze for you.
我們要對空氣濾清器的工作原理有所了解，車輛啟動時，發動機在吸入空氣和燃油混合之前，空氣濾清器的功能就是濾掉空氣中的灰塵、碳、部分的水蒸氣及其它的雜物，從而保證清潔的空氣進入到氣缸中。
We need to understand the working principle of the air filter. When the vehicle starts, the function of the air filter is to filter out the dust, carbon, some water vapor and other impurities in the air before the engine inhales air and mixes fuel, so as to ensure that clean air enters the cylinder.
在理論上每單位體積的燃油燃燒時，大約需要1萬單位體積的清潔空氣。一般情況下，制造商空氣濾清器正常維護的更換周期為4.8萬Km,且每2.4萬Km要進行一次常規檢查；所以保守的維護更換周期為2.4萬Km，攪拌車所處的工作環境比較差，維護周期要相應的減少一些。
In theory, 10000 units of clean air are required for the combustion of fuel per unit volume. In general, the manufacturer recommends that the replacement cycle for normal maintenance of the air filter is 48000 km, and a routine inspection should be carried out every 24000 km; Therefore, the conservative maintenance and replacement cycle is 24000 km, and the working environment of the mixer is relatively poor, so the maintenance cycle should be reduced accordingly.
在大氣中含有三種密度不同的基本顆粒污染物，即灰塵、殘?jiān)吞剂?。如果是在開放式的高速公路上，灰塵的含量較建筑工地低一些，灰塵濃度較大的區域，即建筑工地，攪拌站，風沙區域，在這些地方工作的攪拌車，它的空氣濾清器的檢驗和更換頻率要高一些；
There are three basic particulate pollutants with different densities in the atmosphere, namely dust, residue and carbon particles. If it is on an open expressway, the dust content is lower than that of the construction site, and the area with higher dust concentration, namely, the construction site, the mixing plant, and the windblown sand area, the inspection and replacement frequency of the air filter of the mixer truck working in these areas should be higher;
而在高速公路和交通比較擁堵的區域，因?yàn)檐囕v的排放物集中，所以空氣中碳的含量明顯偏高，對于濾清器的檢查更應該仔細，尤其是濾清器的內部褶皺處；有時候，濾清器的外部看似清潔，但是其實內部已經非常臟了，因此須盡快更換。
In expressway and traffic jam areas, because of the concentration of vehicle emissions, the carbon content in the air is obviously high, so the filter should be checked more carefully, especially the internal wrinkles of the filter; Sometimes, the outside of the filter looks clean, but the inside is very dirty, so it must be replaced as soon as possible.
對于攪拌車的空氣濾清器什么時候該更換，你們都了解了嗎？以上所講解的內容希望能夠給您好的幫助，您對此有什么問題或者需求隨時來我們網站http://www.jbckj.cn咨詢了解吧！
Do you know when the air filter of the mixer should be replaced? I hope the above explanation can help you. If you have any questions or needs, please come to our website at any time http://www.jbckj.cn Ask and understand!
